Results 1 to 19 of 19

Thread: 1996Battlewagon's 2005 Outback H6 (Potential Expo Rig)

  1. #1
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.

    1996Battlewagon's 2005 Outback H6 (Potential Expo Rig)

    Sup fellas! After wrenching on my 05 Outsack for the past week replacing the power steering pump, accessory belt, and power steering feed hose/o-ring, I've decided this car is easy enough to work on and tough enough to be modded.

    This is my DD and will remain that way for as long as I can't afford an '10-'14 3.6R sedan. As of 9/11/16 it has 171k miles and is stock with the exception of an aftermarket Bluetooth hookup installed by the previous owner.

    The car has been well taken care of. Rear wheel bearings have been replaced as well as rear struts, and steering rack. It's been fed synthetic oil for a majority of its life and will continue to. The engine rocks! No leaks but does burn a bit of oil when trashed on (read wide open throttle).





    Gratuitous flex shots:





    Mods as of 9/11/16:

    Engine:
    Stock
    Transmission:
    Stock
    Suspension:
    Stock
    Tires:
    225/55/17 Firestone
    Brakes:
    Stock
    Interior:
    Kinko Bluetooth receiver
    Exterior:
    Stock

    My plan here is to build a light-duty expo rig that my GF can still drive in the winter.

    I've raided RalliTEK and Primitive Racing's catalog's and have a somewhat decent plan (albeit expensive):

    Front and rear skid plates
    King Springs/KYB Struts (had this set up on my BG and loved it!)
    225/60/17 Yokohama Geolander AT/S
    Cloth front seats (the leather is getting too old and hard to be comfortable on long trips)
    A pillar lights (I really want these but will have to fab up some sort of mount)

    A big maybe put all possible:
    Rooftop tent
    Magnaflow mufflers

    Maintenance wise, the car needs new brake rotors pretty bad. One if not multiple are warped right now.
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  2. #2
    SLi O.G. Muse's Avatar
    Join Date
    Jul 2012
    Location
    Lebanon, CT
    Posts
    2,303
    Points
    10,774
    Level
    68
    Points: 10,774, Level: 68
    Level completed: 81%, Points required for next Level: 76
    Achievements:
    VeteranOverdrive10000 Experience Points
    This should be totally awesome.
    Space Unicorn - 1995 Legacy L wagon. Silver/black, with planets. 5mt. (Dead, but not gone, yet.)
    1997 Legacy Brighton wagon. White. (Parts car, scrapped.)
    Grace - 1995 Legacy L wagon. WGM. (Sold for scrap. RIP.)
    Luna - 1993 Honda Civic Del Sol Si (Sold and deeply missed.)
    2000 Legacy Brighton wagon. White.(Blown HG, awaiting transplant)

    Quote Originally Posted by Lancaster6
    A sherpa could rip ass somewhere high up in the Himalayas and my Prius will be blown almost off of the road.

  3. #3
    SLi O.G. 98legwag's Avatar
    Join Date
    Mar 2011
    Location
    Moco, Maryland
    Posts
    3,492
    Points
    16,957
    Level
    83
    Points: 16,957, Level: 83
    Level completed: 22%, Points required for next Level: 393
    Achievements:
    Social10000 Experience PointsOverdriveO.G.Recommendation Second Class
    Awards:
    User with most referrers
    Another 3.0R! We are slowly taking over!

  4. #4
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    For good reason: this engine is fantastic! Don't get me wrong, I have a soft spot in my heart for the EJ25D, but a timing chain, torque, power, and smoothness kind of trump the four bangers as a DD in my mind. Even with 171k miles, this thing still hauls!

    I will say the 5EAT sometimes downshifts at slow speed a bit harshly. The fluid has been flushed within the past year, so maybe it's just old age. Perhaps an aftermarket trans cooler would help.

    This weekend, I'd like to try and permanently mount a GPS. Stay tuned.
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  5. #5
    SLi O.G. 98legwag's Avatar
    Join Date
    Mar 2011
    Location
    Moco, Maryland
    Posts
    3,492
    Points
    16,957
    Level
    83
    Points: 16,957, Level: 83
    Level completed: 22%, Points required for next Level: 393
    Achievements:
    Social10000 Experience PointsOverdriveO.G.Recommendation Second Class
    Awards:
    User with most referrers
    From what I have heard, its also the way the TCU is programmed. Some people have said there is an update for that, but I am not sure. As for the GPS mount, I bought this one:

    http://www.cubbymounts.com/2005-2009.html

    I really like it.

  6. #6
    ROTM Master peugoby's Avatar
    Join Date
    Sep 2006
    Location
    Seattle, WA
    Posts
    1,250
    Points
    14,689
    Level
    78
    Points: 14,689, Level: 78
    Level completed: 60%, Points required for next Level: 161
    Achievements:
    10000 Experience PointsO.G.
    Congrats! Looks like a great daily driver. It looks like its in great shape too. If I ever end up buying another Legacy, it'll be an '09 3.0R Outback Limited.
    '95 Subaru Legacy L AWD Wagon - Original Owner lBBS l CUSCO l WHITELINE l SPT
    '88 BMW E30 325 Sedan
    '18 VW Alltrack SE DSG

  7. #7
    SLi Lurker foohfooh's Avatar
    Join Date
    Jan 2013
    Location
    Seattle/San Diego
    Posts
    434
    Points
    5,362
    Level
    47
    Points: 5,362, Level: 47
    Level completed: 6%, Points required for next Level: 188
    Achievements:
    Veteran5000 Experience Points
    Ah. That car is a holy grail. Remember that guy mshiv? From australia? I think that's what he had.

  8. #8
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Quote Originally Posted by 98legwag View Post
    As for the GPS mount, I bought this one:

    http://www.cubbymounts.com/2005-2009.html

    I really like it.
    Interesting. Pretty reasonable price wise. I do kind of like that cubby though - I might try and mount it by the shifter.
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  9. #9
    "FNG"
    Join Date
    Jun 2009
    Location
    Inland Empire
    Posts
    30
    Points
    5,624
    Level
    48
    Points: 5,624, Level: 48
    Level completed: 37%, Points required for next Level: 126
    Achievements:
    O.G.5000 Experience Points
    Looking forward to the build!

  10. #10
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Well fellas, after dealing with the nonsense of life, I'm finally starting to hunt for parts for this thing. Car is still stock and has been driven by my girlfriend for the past three weeks while her e90 sat. That car finally went to a real mechanic (newer BMWs baffle me) and I'm getting my car back soon! I went back and forth on the direction for this car (overlander or supercharged sleeper) and decided to continue on with my expo-style build. I'm putting together a parts list to refresh the suspension and make the car a bit tougher. Here's what I have planned. Open to comments and suggestions:

    Suspension:
    All new KYB GR2s for 05-09 Outbacks
    Strut "rebuild" kit from Primitive Racing
    H6 Specific King Raised Springs
    Moog Problem Solver end links front and rear
    Energy Suspension front sway bar bushings

    Brakes:
    Hawk front rotors with HPS 5.0 pads
    Stoptech rear rotor and pad kit

    Armor:
    Primitive Racing front skid plate
    Primitive Racing rear diff skid plate

    I think in total that's around $2k worth of parts, shipping included.

    I also want new tires but want to keep the 17s. Shooting for 225/60 Geolander A/T-S's.

    Thoughts on other suspension bits while I'm under there? I thought about a thicker rear sway bar, but then thought against it due to the Kings. Maybe I should just try new bushings or the AVO reinforcement bracket?

    Also, what about lower control arm bushings? I'm sure mine are shot - should I just stick with OEM or try and go aftermarket?

    Oh, and I need to get a heavier duty hitch to tow trailers - any thoughts there?

    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  11. #11
    SLi O.G. 98legwag's Avatar
    Join Date
    Mar 2011
    Location
    Moco, Maryland
    Posts
    3,492
    Points
    16,957
    Level
    83
    Points: 16,957, Level: 83
    Level completed: 22%, Points required for next Level: 393
    Achievements:
    Social10000 Experience PointsOverdriveO.G.Recommendation Second Class
    Awards:
    User with most referrers
    For the control arms you can get Mevotech aluminium control arms loaded with solid rubber bushings and new ball joints from Rock Auto. I did that on my Legacy 3.0R and it was a very nice improvement. The cost was roughly the same as getting new bushings and having them pressed in. I also did not realize I needed the ball joints until my friend and I took off my old LCAs. It was a nice bonus that they come with the Mevotech LCAs.

  12. #12
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Oh man, thank you for that! Just so I'm sure, you're talking these, right?

    http://www.rockauto.com/en/moreinfo....430736&jsn=356

    http://www.rockauto.com/en/moreinfo....430736&jsn=355

    I'll have to add them to the list. The ball joints were replaced recently, but these look like a nice upgrade. I wonder if they're lighter than the OEM control arms? They seem like they would have to be.

    Did you "feel" a difference when you installed them, other than perhaps having new ball joints haha!
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  13. #13
    SLi O.G. 98legwag's Avatar
    Join Date
    Mar 2011
    Location
    Moco, Maryland
    Posts
    3,492
    Points
    16,957
    Level
    83
    Points: 16,957, Level: 83
    Level completed: 22%, Points required for next Level: 393
    Achievements:
    Social10000 Experience PointsOverdriveO.G.Recommendation Second Class
    Awards:
    User with most referrers
    Those are the ones I got. The ball joints are a little beefier than the normal Legacy parts. My friend said they look more like STI ball joints. Someone else said they are about 2 lbs lighter than the steel LCAs. I notice less bump steer and my car feels a little more composed after the change. My bushings in the stock LCAs were pretty trashed. I am very pleased with the results.

  14. #14
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Long time no update, mostly because the car hasn't changed much. Winter happened in Rochester, so I "lost" the car for eight months while my GF drove it during the winter (I lost it again shortly after, but I'll get to that). I did buy a new set of snowshoes for it though - 215/65R16 General Altimax Artic 12s using Summit Racing steel wheels. While I would have preferred some OEM Subaru 16" alloys, I coudn't find any used that I liked in enough time for the various snow storms we were having. Plus, I did managed to take the car out in some snow with the 17" Bridgestones and man was it slick. The car could barely stop and steer at the same time. The GF was in danger!

    Subaru Snow Tires by Logan Utsman, on Flickr

    With the Generals though, it's a point and shoot affair. These tires on this car make for the ultimate snowmobile!

    I didn't drive the car much during winter, but did get to bond with it in March. Took it on a quick "overland" trip in Southern Ohio while my GF went dress shopping in Cleveland with her sister. Went through a bunch of dirt roads in national forests and camped for a night. Kept the snow tires on for better off-road traction and honestly, a softer ride. Check out a blog post I wrote about it here: https://emptyroadchronicles.com/2018...at-six-subaru/

    Southern Ohio Roads by Logan Utsman, on Flickr

    2005 Subaru Outback by Logan Utsman, on Flickr

    Subaru Camping by Logan Utsman, on Flickr

    That brings us to today... er two days ago when the car failed its first ever New York State inspection. The tech was kind enough to let me go without a failed sticker, so I still have a temporary tag on it (expired) but I honestly think if I took it somewhere else, it would pass. They wouldn't pass me for rear lateral link/trailing arm bushings (these are legitimately blown, I will say), a torn CV boot (which the guy said he would need to replace the entire axle because "they don't sell the boots anymore" which is simply incorrect - I bought a new boot yesterday), and, while he said he wouldn't have marked me for it, the disks have a lip in them and that could be a fail point too (they're rusted and LOUD).

    This irritated me because of all the crappy rust buckets I see rolling around town with inspection stickers. Having grown up in a state where you can register anything as long as it has a VIN, this whole inspection process seems like a racket to get the state money, and the various shops around town the opportunity to get more money from people who don't understand cars. When I told the guy "thanks, but I'll replace all this on my own" I think it clicked that he wasn't getting any money from me and he let me go. Good on him, but man, this is annoying.

    While disapointing, the inspection fail did give me the motivation to buy new parts for this car again! It's been about 10 months since I did anything major to it (last big repair was front control arm bushings) other than brake pads, a new caliper (the old one was leaking) and a couple of oil changes and I really don't want to sell the car because it's been so good to the GF and me. So, I'm spoiling it!

    Here's what I orded yesterday:
    • CV Boot
    • Centric "premium" brake rotors front and rear
    • Whiteline adjustable rear lateral links
    • KYB struts front and rear
    • RalliTEK 0" front coils and 0.4" rear coils


    I ordered the struts and springs fully assembled with new dust boots and bumpstops. RalliTEK was kind enough to let me know the rear springs were on backorder and wouldn't be available until mid August. I contemplated switching out for Kings, but like the fact that the RalliTEK springs are softer which will be nice for the GF (this is her primary car now - the E90 was totaled in a wreck a few weeks agon unfortunately). So, I'm waiting for those to come in. I might try to take it somewhere else in the meantime to get a "second opinion" on the inspection so I can at least get a colored tag.

    I really like going on extended road trips and I love camping, but the GF is more on the high brow side of adventure than I am (I'm totally cool with misery). My daily driver is a stock Jeep Cherokee two door that is more than capable of handling these trips, and while she digs it, the A/C doesn't work and she prefers riding in the Subaru on long trips (more creature comforts and quieter). So, my thought process for "modifying" this car is to make it even more enjoyable for me when we go on trips. I want to be able to bomb down dirt roads if I see them with more confidence, and I really want to be able to be more comfortable. The leather seats have become hard as a rock and my butt goes numb after about an hour. So, once my credit card cools down, I'm going to hopefully buy a set of tan, heated cloth seats for the front (if I can find them) and finally get the skid plates.

    That's it for now. Expect more when my suspention parts come in! I going to attempt to replace all these parts on my own.
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  15. #15
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    After a month of waiting on backorder springs from Rallitek, I got all my parts! I'm super excited but overwhelmed by all the work that's ahead of me. I fortunately have a well-skilled friend who has a solid Subaru wrenching past on hand because I want to get this all installed and aligned in three days. I'll be using hand tools mostly, but I am going to splurge and at least get a nice electric impact. That should help. I'm a slow worker by myself.

    PES Parts_9.14.18 by Logan Utsman, on Flickr
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  16. #16
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Welp, she's "done"... for now.

    Subaru Outback 3.0 by Logan Utsman, on Flickr

    Got the struts/springs, rear control arms, rotors and skid plates on. Plus, a brand-new driver-side axle and an inspection sticker. I "buffed" the headlights, but the driver-side one is pretty scored. They're at least not foggy anymore! Oh, and clearly it's on snows again.

    I did the front-end work myself with some help from my buddy. I encountered one stuck bolt - the driver-side upper strut/camber bolt was frozen in the hub/strut assembly. Penetrating oil and a big breaker bar finally got it loose enough to rotate, then I rubber hammered it out while turning it with a ratchet.

    I got connected with a dealer tech who specialty is Subarus (it's one of those joint brand dealers where the predominate make is Chevrolet) and he did the rear work for me. I'm so glad he did because he had to torch one of the rear lateral link bolts out by basically melting the bushing.

    The car rides and handles so much better than before. Steering is tight and sharp. Body sway is much more under control and limited. Braking even improved with the new rotors and having front and rear skid plates is confidence inspiring.

    As a born-and-raised southerner, I can't believe I'm saying this, but I'm really looking forward to Rochester's first real snow fall of the season!
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  17. #17
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Here are some recent pictures. This thing rocks.

    Name:  IMG_20181215_082354.jpg
Views: 64
Size:  132.5 KB

    Name:  IMG_20181215_082541.jpg
Views: 62
Size:  125.8 KB

    Name:  IMG_20181215_082659.jpg
Views: 64
Size:  146.3 KB

    Name:  IMG_20181215_084516.jpg
Views: 67
Size:  175.2 KB
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  18. #18
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Name:  00000IMG_00000_BURST20190121160719623_COVER.jpg
Views: 45
Size:  129.9 KB

    Once again, this thing has earned its stripes. Rochester got a pretty decent amount of snow finally - about 2' of the stuff. I left the two Jeeps in the garage as this is honestly better suited for these conditions - especially as the streets are mostly plowed and often hard packed. When it was much deeper, it still just plowed through everything and stopped like it should. The skid plate, tires, rear limited slip and smooth H6 power really add up to capable snow machine. I've been having way too much fun!
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

  19. #19
    SLi Resident 1996Battlewagon's Avatar
    Join Date
    Aug 2007
    Location
    Rochester, NY
    Posts
    942
    Points
    9,470
    Level
    65
    Points: 9,470, Level: 65
    Level completed: 40%, Points required for next Level: 180
    Achievements:
    5000 Experience PointsO.G.
    Summer time! Got some new shoes for ole' Planet Express Ship. 225/60R17 Continental TerrainContact A/Ts. A little snug in the wheel wells, but nothing rubs so far. The front-most rear mud flap is awfully close though. I'm sure whatever interference there is (most likely under compression) will just rub away after time.

    Name:  IMG_20190424_174736.jpg
Views: 24
Size:  145.4 KB

    Name:  IMG_20190424_174752.jpg
Views: 24
Size:  150.6 KB

    Name:  IMG_20190424_174813.jpg
Views: 24
Size:  136.0 KB

    Name:  IMG_20190424_174803.jpg
Views: 23
Size:  125.2 KB
    Current:
    2005 Legacy Outback H6 (Battlewagon 2.0)
    Former:
    1999 Legacy Outback 2.5 5sp
    2002 Legacy Outback H6
    1997 Legacy Outback 2.5 5sp (Battlewagon 1.0)
    1996 Legacy L Wagon

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •